Wednesday, August 17, 2011

Evans Plegazair 100, N523RE: Accident occurred August 17, 2011 in Maysville, North Carolina

NTSB Identification: ERA11LA459 
 14 CFR Part 91: General Aviation
Accident occurred Wednesday, August 17, 2011 in Maysville, NC
Probable Cause Approval Date: 02/06/2012
Aircraft: EVANS ROBERT W SR PEGAZAIR 100, registration: N523RE
Injuries: 1 Serious.

NTSB investigators may not have traveled in support of this investigation and used data provided by various sources to prepare this aircraft accident report.


The student pilot was making his first takeoff in his experimental light sport airplane and had the flaperons extended. He added power, and the tail of the airplane came off the ground quicker than he expected. The airplane became airborne at 30 mph in a nose-high attitude. He stated that the airplane stalled, rotated 180 degrees, and collided with the ground. The student pilot stated that there were no mechanical problems with the airplane and that he did not have a tailwheel endorsement or training in tailwheel airplanes. Review of the manufacturer's specifications revealed that the airplane will stall at 28 mph. Postaccident examination of the airframe, flight controls, engine assembly, and accessories revealed no anomalies that would have precluded normal operation.

The National Transportation Safety Board determines the probable cause(s) of this accident to be:
The student pilot's failure to maintain adequate airspeed during initial takeoff climb, which resulted in an aerodynamic stall.

On August 17, 2011, at 0740 eastern daylight time, an experimental amateur-built light sport, Evans Plegazair 100 airplane, N523RE, registered to a private owner, collided with the ground during initial takeoff climb from a private airstrip in the vicinity of Maysville, North Carolina. The personal flight was operated under the provisions of 14 Code of Federal Regulations Part 91. No flight plan was filed and visual meteorological conditions prevailed. The student pilot sustained serious injuries. The airplane received structural damage to both wings and the empennage. The flight was originating from the student pilot's private airstrip at time of the accident.

The student pilot stated he did not have a tail wheel endorsement or training in tail wheel airplanes. In addition, the accident takeoff was his first takeoff with the flaperon extended to 20 degrees. He started the takeoff run and the airplane responded differently. The tail came up quicker than he anticipated, in a nose-high attitude, about 30 mph or slower. The left wing dropped down, and the nose of the airplane veered to the left. The student pilot stated he had no memory of the accident from that point, other than there was nothing wrong with the airplane.

A friend of the student pilot stated he observed the airplane during takeoff with the flaps extended about 20 degrees. The airplane became airborne and climbed between 100 to 150 feet. The nose of the airplane was in a high attitude and the left wing dropped down. The airplane veered to the left as if it was in a stall and rotated 180 degrees, before it collided with the ground in a nose-down attitude. The friend stated there was no change in engine noise until the airplane collided with the ground.

Review of records on file with the Federal Aviation Administration (FAA), Aircraft Registration Branch revealed the original builder applied for an aircraft registration certificate on October 26, 2005. Review of the aircraft logbooks revealed the student pilot certified that he had built the aircraft for his own education and recreation on November 23, 2007. He had inspected the airplane fully and he considered it was eligible for issuance of an airworthiness certificate. The student pilot was issued a special airworthiness certificate and experimental amateur-built limitations on March 1, 2008. Review of the aircraft logbooks revealed the last condition inspection was conducted on March 1, 2008. The next inspection was due on March 31, 2009. The student pilot stated in an interview with the NTSB investigator-in-charge that he completed the last condition inspection about 1 month before the accident, but he did not record it in the logbook. On October 3, 2008, the logbook entry stated, "A/C under powered!!Removed EA-81!! ". Installed Lycoming O-320 serial number 3876-27 with in flight adjustable IVO magnum. Installed used rpm tachometer with reading of 2476.18." The airplane was involved in an accident on January 29, 2009, at recorded tachometer time of 2480.0.

The wreckage was located in a cotton field adjacent to a private residence in the vicinity of Maysville, North Carolina. The airplane collided with the ground in a left wing low, nose-down attitude and came to rest on a heading of 270-degrees magnetic. The composite propeller blades were fragmented and remained attached to the propeller hub. The top of the engine cowling was separated. The engine assembly was displaced to the left, upward, and remained attached to the engine mounts with all accessories. The engine firewall was bucked.

The windshield supports remained intact; however, the windscreen popped out. The left and right cabin doors remained attached to the door post and both side windows were intact. The cabin roof was wrinkled. Both cabin seats remained intact and the pilot's restraint system was in use at the time of the accident. The instrument panel was intact and damaged. The tachometer at the accident site read 2485.0 hours. The fuel selector switch was in the off position. The interconnected throttle on the pilot's side was full forward. The right side throttle was full aft. The mixture knob was full rich. The flaperons were extended 20 degrees. Continuity of the flight controls was confirmed from the cockpit aft to all flight control surfaces. The right main landing gear remained attached to the airframe. The left main landing gear was partially attached to the airframe and bent outward.

The right wing remained attached at the wing root. The leading edge of the wing received damage from the wing tip extending inboard 5 feet. The upper and lower wing skins were wrinkled. The right main fuel tank was not ruptured and fuel was present in the fuel tank. The right main fuel cap was secure with a tight seal. The right flaperon remained attached at all hinge points and was extended 20 degrees. The right wing strut remained attached to the wing and the fuselage.

The empennage was not damaged. The vertical fin was intact and not damaged. The rudder remained attached to the vertical fin and was not damaged. The rudder balance weight was intact. The left and right horizontal stabilizer and left and right elevators were not damaged. The tail wheel remained attached to the fuselage and was not damaged.

The left wing remained attached at the wing root. The trailing edge of the left wing separated from the rear spar. The leading edge of the wing received damage from the wing tip extending inboard 10 feet. The upper and lower wing skins were wrinkled. The left main fuel tank was not ruptured and fuel was present in the fuel tank. The left main fuel cap was secure with a tight seal. The left attachment fitting separated from the left flaperon. The left wing strut remained attached to wing and the fuselage.

Visual examination of the engine assembly and accessories revealed no anomalies.

Review of the Pegazair 100 specifications revealed that at a gross weight of 1,450 pounds, with 20 degrees of flaps extended, the airplane will stall at 28 mph.


WITN's Carly Swain was on the scene in Maysville off of White Oak River Road. Officials told her the pilot, Robert Evans, is a local farmer who owns the plane and a private air strip. Evans has a broken arm and possibly a broken leg. He's been transported to the hospital.

Evans told officials he felt the plane bank left just after taking off. The wing got caught up in the some of his crops and spun around 180 degrees.

The emergency call went out just before 8 a.m. this morning. Jacksonville Volunteer Rescue Squad and the Belgrade Volunteer Fire Department responded.

Federal Aviation Administration spokeswoman Kathleen Bergen says her office is investigating the accident.

She says the aircraft was a Pegazair 100.

http://www.witn.com
http://www2.wnct.com
http://www.jdnews.com

No comments:

Post a Comment