McDaniel RV-6-CH, N424D: Fatal accident occurred November 26, 2012 in Scio, Oregon

Aviation Accident Final Report - National Transportation Safety Board: http://app.ntsb.gov/pdf 

Docket And Docket Items - National Transportation Safety Board:   http://dms.ntsb.gov/pubdms

Aviation Accident Data Summary - National Transportation Safety Board: http://app.ntsb.gov/pdf

NTSB Identification: WPR13FA056 
14 CFR Part 91: General Aviation
Accident occurred Monday, November 26, 2012 in Scio, OR
Probable Cause Approval Date: 01/20/2015
Aircraft: MCDANIEL RV-6-CH, registration: N424D
Injuries: 2 Fatal.

NTSB investigators either traveled in support of this investigation or conducted a significant amount of investigative work without any travel, and used data obtained from various sources to prepare this aircraft accident report.

The purpose of the flight was for the pilot-rated passenger to show the owner/pilot how to perform rolls in the experimental kit-built airplane. A witness reported observing the airplane in level flight about 1,000 feet above ground level before it entered a steeply banked turn. The airplane was halfway through the turn when the right wing folded up over the fuselage. The wing departed the airframe, and the airplane rapidly descended to the ground. The right wing was located about 1,090 feet from the main wreckage. 

The owner/pilot was not the builder of the airplane, and he had no record of aerobatic flight experience. The pilot-rated passenger's logbook indicated that he had made a single 0.5-hour flight in another RV-6 that included performance of rolls and wing-overs. 

The operating limitations document for the airplane noted that aerobatic flight was prohibited unless such flights were satisfactorily accomplished and recorded in the aircraft logbook during its flight test period. No entries were found in the logbook that would satisfy this requirement. 

Postaccident examination of the separated right wing determined that the upper and lower spar-caps had failed in buckle and overload. Although the airplane was registered with the Federal Aviation Administration by the builder as an RV-6-CH model, the design of its spar caps was found to be substantially different from the kit manufacturer's design for the RV-6 model airplane, a model which can be approved for aerobatic maneuvers. Rather the design was similar to the wing cap spar design for the older RV-3 model airplane, a design which was found to be susceptible to failure in buckle when exposed to aerobatic flight. Following a number of inflight wing failures in RV-3 airplanes during aerobatic flight, the kit manufacturer recommended that no aerobatic maneuvers be performed in RV-3 model airplanes until wing spar modifications that increase the spar's stiffness and resistance to buckling have been accomplished. Because the purpose of the flight was performance of an aerobatic maneuver (rolls) and because the airplane's wing spar cap design was not suitable for aerobatic flight, it is likely that at some point during the flight, an aerobatic maneuver was performed that weakened the wing, and the final steep turn was then sufficient to overload the wing.

Toxicology results showed that the owner/pilot had therapeutic levels of diphenhydramine, a sedating antihistamine, in his system; however, it could not be determined if he was flying at the time of the accident or if this impairment contributed to the accident.

The National Transportation Safety Board determines the probable cause(s) of this accident as follows:
The pilot's decision to perform aerobatics in an airplane that was prohibited from aerobatics as stated in its operating limitations document, which resulted in the failure of the right wing spar.

HISTORY OF THE FLIGHT

On November 26, 2012, at 1537 Pacific standard time, a McDaniel RV-6-CH, N424D, collided with terrain after its right wing departed the airplane 5 miles south of Scio, Oregon. The airplane was registered to, and operated by, the pilot under the provisions of 14 Code of Federal Regulations, Part 91. The private pilot and the commercial pilot were fatally injured. The airplane was substantially damaged. Visual meteorological conditions prevailed, and a flight plan had not been filed. The personal flight originated at the Lebanon State Airport, Lebanon, Oregon, at 1531.

A witness described observing the airplane at 1,000 feet above ground level (agl). When the airplane was halfway through a turn, one of the wings folded up. The airplane then rapidly descended to the ground. The Linn County Sheriff's office reported that the airplane's right wing was located on Highway 226, and the main airplane wreckage was located in a pasture 1,090 feet south of the wing.

The Fixed Base Operator (FBO) proprietor at Lebanon State Airport stated that the pilot and commercial pilot-rated passenger were acquaintances. The pilot arrived earlier that day at Lebanon State Airport and met up with his passenger. The passenger had a set of portable remote cameras that he was going to mount onto the foot step on the airplane to video record the flight. Additionally, the pilot-rated passenger intended to show the pilot how to perform rolls.

PERSONNEL INFORMATION

The pilot, age 46, held a private pilot certificate with ratings for airplane single-engine land and instrument airplane, issued June 4, 2010. He additionally held a third-class medical certificate with the limitation that he wear corrective lenses, issued April 2, 2012. Examination of the pilot's logbook revealed that as of November 25, 2012, he had accumulated 1,005.0 total flight hours of which 48.5 hours were in the accident airplane. On June 8, 2012, he received a tail wheel endorsement, an endorsement to act as pilot-in-command in a Vans RV-6 or RV-7 series aircraft, and a flight review. No record of aerobatic instruction was found in his logbook.

The passenger, age 45, held a commercial pilot certificate with an airplane single-engine land rating issued June 26, 2012, and a second-class medical certificate with the limitation that he wear corrective lenses issued on May 22, 2005. Examination of his logbook revealed that he had accumulated 590 total flight hours as of November 23, 2012, and his most recent flight review was on February 8, 2012. The logbook showed a single entry dated November 5, 2012, for 0.5 hours in a RV-6A, and the comment line states, "Rolls & wing overs." No other entries were found that included experience in Vans RV model of airplanes or of aerobatic instruction.

AIRPLANE INFORMATION

The two seat, low wing, fixed gear, tail-wheel configured airplane, serial number AC-3, was an experimental amateur-built airplane manufactured in 1996. The majority of the airframe was designed and built by an individual that was previously employed at Van's Aircraft. A second party bought the partially constructed airplane and completed the construction. The airplane was purchased by the pilot on May 29, 2012. The date of manufacture that is recorded on the FAA registration is 1996. The Federal Aviation Administration (FAA) letter defining N424D's Experimental Operating Limitations was dated May 17, 1996. Under Phase II of the Experimental Operating Limitations, subsection titled "The Following Limitations Apply Outside of Flight Test Area", line 4 states, "This aircraft is prohibited from acrobatic flight, unless such flight were satisfactorily accomplished and recorded in the aircraft logbook during the flight test period." Examination of the airplane's maintenance logbooks did not include any such entry that would satisfy this requirement.

The airplane was powered by a Continental IO-346-A, 165-horsepower engine, and equipped with a wooden fixed-pitch propeller. A review of copies of the airplane maintenance logbooks revealed that the most recent conditional inspection was performed on May 25, 2012, at a total airframe time of 557 hours. 

Although the airplane was designated an RV-6-CH and closely resembled the Van's RV-6 model of airplane, there were numerous differences between the accident airplane and the kit design that Van's Aircraft produces. The wing span of the accident airplane, as measured after the accident, was 22 feet. In contrast, the Van's RV-3 wing span is 20 feet, and the Van's RV-6 is 23 feet. There were additional differences in the wing spar construction. The wing spar construction of the accident airplane utilized the same materials and general design as the Van's RV-3 series of designs and the wing appeared to be a modified and extended version of the RV-3 wing. The original Van's RV-3 wing spar design consists of a 0.040 aluminum channel web with a build-up of seven 0.125 by 1.25-inch bars riveted together on to form the upper and lower spar caps. The accident airplane's spar consisted of a build-up of 4 pieces of aluminum channel web with nine 0.125 by 1.5-inch aluminum bars for the upper and lower spar caps. In contrast, the Van's RV-6 uses 2 pieces of 0.040 2043-T3 aluminum channel web with a build-up of four 0.250 by 1.5-inch aluminum bars plus one 0.125 by 1.5-inch bar.

MEDICAL AND PATHOLOGICAL INFORMATION

An autopsy was performed on the pilot on November 11, 2012, by the Oregon State Medical Examiner, Clackamas, Oregon. The cause of death was listed as "blunt force injuries of head and chest."

The FAA Forensic Toxicology Research Team performed toxicology on specimens from the pilot with positive results for diphenhydramine detected in blood (0.604 ug/ml), and ethanol detected in muscle (20 mg/dl), no ethanol was detected in the brain. Diphenhydramine is a sedating antihistamine used to treat allergy symptoms and as a sleep aid. It is available over the counter under various trade names including Benadryl and Unisom. Diphenhydramine carries the following warning: may impair mental and/or physical ability required for the performance of potentially hazardous tasks (e.g., driving, operating heavy machinery). There was an insufficient specimen amount to test for carbon monoxide, and the test for cyanide was not performed.

An autopsy was performed on the pilot-rated passenger November 27, 2012, by the Oregon State Medical Examiner, Clackamas. The cause of death was listed as, "Craniocerebral and chest trauma." The FAA Forensic Toxicology Research Team performed toxicology on specimens from the passenger with negative results for carbon monoxide, screened drugs, or ethanol.

WRECKAGE AND IMPACT INFORMATION

The right wing was located on a highway paved with asphalt. The wing root and 2-3 rib bays had been crushed longitudinally into the wing. The inboard portion of the main wing spar, in the vicinity of the longitudinal crushing, was buckled in the shape of a double-S. Located in the center of the highway there was an indentation in the asphalt that was consistent with wing impact, and in the adjacent area was the odor of aviation fuel and fuel stains were observed. The wing's aft spar doubler plate was not present on the spar. The upper and lower spar caps were bent aft and outward, pointing down the wing span towards the wing tip. The lower spar-cap of the rear spar, at the attach bolt-hole location, was missing a section of material originating at the bolt hole. The aileron and flap were present on the wing, the aileron control rod was connected to the aileron, and the control rod had separated at the wing root. The wing skin did not exhibit any wrinkling or buckling.

A debris field extended from the right wing to the main wreckage and mostly consisted of Plexiglas fragments, and small cockpit items. The reported remote video camera that may have been mounted to the foot step was not located. Blister packs of Nicorette (4mg/piece) and Benadryl Allergy (25mg Diphenhydramin HCl liquid-gels) were identified in the debris.

The main wreckage was located about 1,090 feet to the south of the right wing, in a grass pasture, resting on its right side. It was oriented from tail to nose on a bearing of 138 degrees magnetic. The wreckage consisted of the left wing, fuselage, cockpit, tail, engine, and propeller. Flight control continuity was established on-scene by manually moving the aileron and elevator control surfaces and observing movement of the control stick in the cockpit area. Control continuity from the rudder to the cockpit was established by tracing the rudder cables from the rudder control surface attachment point to the rudder pedal cable anchors on the rudder pedals. The left horizontal stabilizer and vertical stabilizer appeared undamaged; the right horizontal stabilizer and elevator exhibited crush damage from ground impact. The left wing laid on top of and in line with the fuselage. The left wing main spar was continuous through the cabin and extended 14 inches into the right wing spar where it was fractured completely at the upper and lower spar caps. In the region of the fracture surfaces the spar ends were bent aft. The upper and lower spar caps were a buildup of 9, 0.125 thick aluminum bars and bolted together with through-bolts positioned every 1.25 inches. The fracture surface of each bar appeared bright and angular, with shear lips. The aft spar of the left wing remained attached to the carry through. The right side of the aft wing spar carry though contained the right wing aft-spar doubler plate and spar attach-bolt.

The cockpit cabin had been completely compromised, and the right side of the engine had imbedded about 2 feet into the ground. The right underside of the engine's case and oil pan had been broken and torn laterally. The right case-half contained a crack at the no. 3 cylinder location. The two magnetos had been displaced from their mounting pads. The right magneto produced spark at three terminals when rotated by hand; the left magneto was seized and could not be rotated by hand. The upper spark plugs were removed. The spark plugs were dark gray in color, all gaps were similar, and no mechanical damaged was observed. The engine was seized and could not be rotated by hand. The fuel distribution valve was intact, no debris was observed in the filter screen, and fuel was observed in the valve. The wood propeller was attached to the propeller hub. One blade was fractured at the hub, the other blade extended out 20 inches from the hub. A majority of wood blade-fragments were recovered with the engine.

TESTS AND RESEARCH

The right-wing spar was sectioned out of the wing, and the wing carry through spar was sent to the National Transportation Safety Board's Materials Laboratory for a detailed examination. The entire Materials Laboratory Factual Report is contained in the official docket for this investigation.

The right wing separated approximately 1 foot from the centerline of the center section. The left wing remained attached to the center section. The wing structure was disassembled on-site from the fuselage to facilitate shipping, handling, and examination. The wing section contained a forward and aft spar. The forward spar at the fracture location contained a total of four reinforcement pieces for the web; nine reinforcement strips (1.5 inch by 0.125 inch) for the upper spar cap; and nine reinforcement strips (1.50 inch by 0.125 inch) for the lower spar cap. Examination of the forward spar revealed that the fracture faces of the lower spar cap at the inboard side contained less mechanical damage compared to those on the upper spar cap pieces.

The aft spar contained an attachment plate with two holes (about 0.75-inch diameter, each). When intact, the attachment plate extended between the aft spar of the center section and the aft spar of the right wing. The attachment plate is designed to be attached by rivets to the upper and lower brackets of the aft spar for the right wing. The inboard end of the plate is designed to be attached by two bolts and corresponding nuts to the aft spar of the center section. Examination of the attachment plate revealed the attachment rivets between the center section and right wing fractured at the shank. The fracture faces of the rivets exhibited metal flow consistent with ductile separation in shear mode. The outboard end of the attachment plate was deformed up and aft relative to the aft spar of the center section. The upper and lower brackets remained attached to the aft spar of the right wing.

Microscope examination of the fracture faces on the forward and aft spar sections of the wing structure and those on the center section showed gray-granular rough features on a slant plane consistent with overstress separation with no evidence of fatigue cracking.

ADDITIONAL INFORMATION

RV-3 History

Van's Aircraft Service Bulletin SB-96-3-1, dated March 25, 1996, states in the synopsis, "After a number of in flight wing failures in RV-3 and RV-3A aircraft. Studies were initiated to identify any possible design deficiencies. These studies resulted in a recommendation by Van's Aircraft and the FAA to limit aerobatic flight of affected aircraft until main wing spar modifications have been accomplished."

The RV-3 wing spar design utilized a spar-cap stack up of 0.125-inch bar stock. This design was found to be susceptible to failure in buckle when exposed to aerobatic flight or high g-loading. An extensive discussion regarding this issue was addressed in Van's Aircraft RV-3 Safety Alert, dated March 25, 1996.

The Van's RV-6 wing spar design resolves the RV-3's spar failure issue by increasing the spar stiffness and resistance to buckling by increasing bar stock thickness from 0.125 to 0.25-inch bar stock in the wing spar stack up and construction.

 http://registry.faa.gov/N424D

NTSB Identification: WPR13FA056 
 14 CFR Part 91: General Aviation
Accident occurred Monday, November 26, 2012 in Scio, OR
Aircraft: MCDANIEL RV-6-CH, registration: N424D
Injuries: 2 Fatal.

This is preliminary information, subject to change, and may contain errors. Any errors in this report will be corrected when the final report has been completed. NTSB investigators either traveled in support of this investigation or conducted a significant amount of investigative work without any travel, and used data obtained from various sources to prepare this aircraft accident report.

On November 26, 2012, at 1537 Pacific standard time, a McDaniel RV-6-CH, N424D, collided with terrain after its right wing departed the airplane 5 miles south of Scio, Oregon. The airplane was operated by the owner under the provisions of Title 14 Code of Federal Regulations Part 91. The private pilot and the commercial pilot were both fatally injured. The airplane was substantially damaged. Visual meteorological conditions prevailed, and a flight plan had not been filed. The flight originated at the Lebanon State Airport, Lebanon, Oregon, at 1531.

A witness described the airplane as being halfway through a turn at 1,000 feet above ground level (agl) when one of the wings folded up on the airplane. The airplane then rapidly descended to the ground. The Linn County Sheriff’s office reported that the airplane's right wing was located on Highway 226, and the main airplane wreckage was located in a pasture 1,000 feet south of the wing.

IDENTIFICATION
  Regis#: 424D        Make/Model: EXP       Description: RV6
  Date: 11/26/2012     Time: 2330

  Event Type: Accident   Highest Injury: Fatal     Mid Air: N    Missing: N
  Damage: Destroyed

LOCATION
  City: SCIO   State: OR   Country: US

DESCRIPTION
  AIRCRAFT CRASHED UNDER UNKNOWN CIRCUMSTANCES, THE 2 PERSONS ON BOARD WERE 
  FATALLY INJURED, 5 MILES FROM SCIO, OR

INJURY DATA      Total Fatal:   2
                 # Crew:   2     Fat:   2     Ser:   0     Min:   0     Unk:    
                 # Pass:   0     Fat:   0     Ser:   0     Min:   0     Unk:    
                 # Grnd:         Fat:   0     Ser:   0     Min:   0     Unk:    


OTHER DATA
  Activity: Unknown      Phase: Unknown      Operation: OTHER


  FAA FSDO: PORTLAND, OR  (NM09)                  Entry date: 11/27/2012 

 

Investigators from the Federal Aviation Administration and National Transportation Safety Board arrived Tuesday at the scene of a small plane crash that killed two men Monday afternoon.

Investigators from the FAA and NTSB examine the remains of a RV6 two-seat airplane Tuesday morning Nov. 27, 2012, that crashed into a field near Crabtree, Ore., after apparently losing a wing inflight Monday afternoon. The wing was found on highway 226 several thousand feet from the crash site. Commericial pilot Jeff Earl "Tebo" Kropf of Halsey, Ore., and aicraft owner Timothy Dean Carter of Portland, Ore., were killed in the crash. 

(AP Photo/Albany Democrat-Herald, Mark Ylen)

 

 Jeff Kropf

 Jeff Earl Kropf, 45, of Halsey and Timothy Dean Carter, 46, of Portland died in the crash 

PORTLAND, Ore. (AP) — The crash of a two-seater experimental airplane this week in the Willamette Valley has shocked people who build their own aircraft from kits or plans. 

 They consider the plane designed by an Aurora company, Van's Aircraft, one of the most popular experimental aircraft in the U.S., saying it's fast, versatile, fuel-efficient and relatively easy to build and fly.

"The performance is great in terms of being able to go both reasonably slow and reasonably fast and to land and take off reasonably short," said Skip Lawson, former president of the Experimental Aircraft Association chapter in Eugene. "They're also known as being over-engineered — they're very strong airplanes."

Witnesses reported that the plane, known by its model number, RV-6, lost a wing when it plowed into a field south of Scio on Monday afternoon, said Linn County Undersheriff Bruce Riley.

The plane's owner, Timothy Dean Carter, 46, of Portland, and his passenger, Jeff Earl "Tebo" Kropf, 45, of Halsey, died.

"I've never heard of a wing coming off an RV aircraft," Dick Knapinski, spokesman for the Wisconsin-based Experimental Aircraft Association, told The Oregonian.

Carter's plane had passed its air worthiness test and was registered with the Federal Aviation Administration, records show. Carter purchased it fairly recently, perhaps in the past year or two, said his oldest daughter, Valerie Tillia. It's not clear whom Carter bought the plane from.

"The nice thing about experimental aircraft is you can modify and change them pretty much at will," said Bob Duncan, a member of the Experimental Aircraft Association chapter in Hillsboro. "But if you buy an airplane from someone else, you need to do the due diligence."

Gus Funnell of Van's Aircraft said the crashed plane appeared to be highly modified and built from plans with custom components, not from a company kit, citing differences in fuselage, cowling and canopy. He said the motor was not the one the plane was designed for.

"We've never had a structural failure in an RV-6," he toldthe Albany Democrat-Herald. "This plane is an RV-6 in name only."

It's easier to use a kit, but people can save money getting their own raw materials, and builders get the satisfaction of creating something themselves, he said.

There are about 33,000 homebuilt planes registered under the Federal Aviation Administration's experimental category. Van's designs account for about 20 percent of the amateur market, with the RV-6 its most popular model. About 6,000 plans and kits for the plane were sold until 2001, when the next model came out.

The accident rate for amateur-built aircraft is up to three times higher than for lightweight manufactured planes, said Loren Groff, safety analyst for the National Transportation Safety Board. The fatality rate is four times higher.

The agency said 86 people have died in RV-6s in the past two decades. Carter and Kropf were the first this year.


Story, video and photos:  http://www.kval.com

By Lynne Terry, The Oregonian on November 28, 2012 at 7:00 PM, updated November 29, 2012 at 6:29 AM  

The two-seat airplane that crashed near Scio on Monday, killing the two men onboard, is one of the most popular experimental aircraft in the United States.

Designed by Van's Aircraft in Aurora, the RV6 is considered something of a hot rod in the air. It's fast, versatile, fuel-efficient and relatively easy to build and pilot, making it a hit when it first came out in 1986.

The company sold  kits and plans of the plane to amateurs to build themselves.

"The performance is great in terms of being able to go both reasonably slow and reasonably fast and to land and take off reasonably short," said Skip Lawson,  former president of the Experimental Aircraft Association chapter in Eugene. "They're also known as being over-engineered -- they're very strong airplanes."

Witnesses reported that the RV6 was banking left and had lost a wing when it plowed into a field south of Scio Monday afternoon, said Linn County Undersheriff Bruce Riley. The plane's owner Timothy Dean Carter, 46, of Portland, and his passenger, Jeff Earl "Tebo" Kropf,  45, of Halsey, died on impact.

» The Linn County crash victims loved flying

Federal aviation officials cleared the accident site on Tuesday. It could take months for officials to determine what happened.

The accident rate for amateur-built aircraft is up to three times higher than for lightweight manufactured planes, said Loren Groff,  safety analyst for the National Transportation Safety Board. The fatality rate is four times higher.

The NTSB said 86 people have died in RV6s in the past two decades. Carter and Kropf were the first this year.

The accident appears to be unique.

"I've never heard of a wing coming off an RV aircraft," said Dick Knapinski,  spokesman for the Experimental Aircraft Association, headquartered in Wisconsin. "It's a very good aircraft."

The accident has shocked experimental airplane enthusiasts, who often spend several years poring over plans, drilling holes and driving in rivets to construct the planes.

There are about 33,000 homebuilt planes registered under the Federal Aviation Administration's experimental category. Van's designs account for about 20 percent of the amateur market, with the RV6 its most popular model. About 6,000 plans and kits for the plane were sold until 2001, when the next model came out.

"It's a fun airplane to fly," said Knapinski. "It's efficient, has good flying characteristics and is very responsive to what the pilot wants to do."

They're even used for aerobatics.

The airplane, 21 feet long with a wingspan of 23 feet, can fly 180 mph. Made mostly out of aluminum, the plane is engineered withstand a stress load -- or gravitational load -- nine times its weight.

That's much more than a human body can withstand without a flight suit. 

 Like all experimental aircraft in the skies, Carter's RV6 had passed its air worthiness test and was registered with the FAA, records show. Carter purchased the plane fairly recently, perhaps in the past year or two, according to his oldest daughter, Valerie Tillia, 26.

It's not clear who Carter bought the plane from. FAA records show it was first registered in 1996 by builders in Amity. David McDaniel confirmed that he made the plane with his father but declined to comment further, saying the plane was sold a long time ago.

Van's Aircraft has no record of selling an RV6 kit or plans to the McDaniels, said Gus Funnell,  a technical expert for the company.

The plane is designed for a Lycoming motor, but Carter's RV6 was equipped with a Continental. Using different engines is not uncommon in the kit airplane world, enthusiasts say.

"The nice thing about experimental aircraft is you can modify and change them pretty much at will," said Bob Duncan, a member of the Experimental Aircraft Association chapter in Hillsboro. "But if you buy an airplane from someone else, you need to do the due diligence."

Tillia believes this was her father's first homebuilt plane.

Carter flew the craft to the Lebanon Municipal Airport on Monday to fill up with fuel and go out on a pleasure ride with Kropf, who worked at the airport and was like a son to the facility's operator, Larry Knox.

"He flew down here and asked (Knopf) to go up with him to do some rolls," Knox said.

Knopf, who earned his commercial pilot's license this spring, had more experience than Carter, Knox said.

Knox said Knopf mounted a camera on the plane before it took off a little before 3:30 p.m. in crisp, sunny weather. The plane crashed about 10 minutes later. A large chunk of the wing landed on Highway 226, nearly 2,000 feet from the fuselage.

It's not clear who was piloting. The RV6 has dual controls.

Though the accident jolted amateur airplane fans, it's not likely to dampen their enthusiasm.

"When you get in a car there's a risk" said Bruce Rose, president of the Hillsboro EAA chapter. "When you cross the street there's a risk and when you get in an airplane there's a risk. Accidents happen." 

http://www.oregonlive.com

Well known Linn County commercial pilot Jeff "Tebo" Kropf was killed when the plane he was riding in crashed near Crabtree on Monday afternoon. Kropf, also known as Tim Corban, had flown hundreds of first-time flyers out of the Lebanon airport in the Young Eagles flight program. 

Firefighters mark wreckage debris east of Brester Road after a plane crash east of Crabtree. 

 

A piece of plane wreckage sits on the side of Highway 226 near Brewster Road east of Crabtree. 

 
Witnesses say the plane was missing a wing when it crashed

 A two-seater RV6 experimental airplane tumbled from the sky Monday afternoon, crashing near Crabtree and killing the two men aboard.

The victims have been identified as Jeff Earl “Tebo” Kropf, 45, of Halsey and Timothy Dean Carter, 46, of Portland.

Carter, the pilot, was the owner of the aircraft and had a private pilot license.  Kropf, the passenger, had a commercial pilot license.

Both  Kropf and Carter died upon impact, Linn County Undersheriff Bruce Riley said in a statement.

Their bodies were taken to Fisher Funeral Home in Albany.

Investigators believe the 16-year-old silver aircraft departed the Lebanon Municipal Airport shortly before 3:30 pm on a pleasure flight.

Witnesses reported seeing the plane eastbound, crossing Brewster Road, banking to the left over Highway 226. While turning to the left, part of the wing became separated from the plane and fell onto Highway 226 north of Brewster Road, Riley said.

The plane came to rest several thousand feet south of the intersection in a field.
Jenissa Currey, 17, said she was driving home from Scio High School, where she is a junior, when she noticed something falling from the sky out of the corner of her eye. It ended up in the middle of a cow pasture about 400 yards from the road.

“It took me a few seconds to realize what it was,” Currey said. “In the back of my mind, I knew it was a plane because what else could it be, but it had only one wing on the plane, and it wasn’t fully put together.”
Currey said it looked as though the plane had broken up somehow while still in flight.

“There were no wings, or if there were they were wrapped around it. It was just a big ball,” said Tom Bishop of Lacomb, who came on the scene on his way to work in Albany minutes after the crash. “All you could see was the tail fin on it, to basically tell you it was a plane.”

The intersection of Highway 226 and Brewster Road was closed for four hours during the investigation.

‘He loved to fly’

Friends and family of Kropf, known to most people in the mid-valley as Tebo, are clear about one thing: he never wanted to stop flying.

Kropf, known as Tim Corban at one point, was the office manager at LebanAir Aviation and the coordinator for Chapter 1524 of the Experimental Aircraft Association’s Young Eagles flight program; the guy who put more than 200 youngsters in the air last year and was well on his way to topping that record.

 “He loved the Lord, he loved his family and he loved to fly,” brother-in-law Alvie Shrock of Brownsville said late Monday.

His first flight was a ride at age 9, in a float plane off a lake near Florence. He had his first lesson at age 16 at Daniels Field in Harrisburg. He became a private pilot in 1996.

His dream was to share the experience, particularly with children who may not see flying as a realistic goal. He also gave a free flight this past January to Paul Miller of Sweet Home, age 101.

“Tebo was such a Renaissance guy. He did photography and flew airplanes and played music and just was an amazing person,” flight instructor Jerry Wilken of Albany said. “Tebo was doing what he loved to do.”

Wilken also flies a RV6. The planes are strong and good at handling both fast and slow speeds, making them one of the most popular small aircraft designs around, he said.

“I don’t know what could have happened,” Wilken said. “Wings shouldn’t fall off of them. They’re built just amazingly strong. ... The way it’s put together, it’s hard for me to believe a wing would just fall off.”


Linn County Undersheriff Bruce Riley reports deputies have learned that two people died as a result of a plane crash that occurred earlier today.
 
The victims have been identified as Timothy Dean Carter, 46 years old of Portland and Jeff Earl Kropf, 45 years old of Halsey.  Carter was the owner of the aircraft and had a Private Pilot License.  Kropf had a Commercial Pilot License. Both Carter and Kropf died upon impact. Their bodies were taken to Fisher Funeral Home in Albany.

Witnesses reported seeing the plane eastbound, crossing Brewster Road, banking to the left over Highway 226. While turning to the left, part of the wing became separated from the plane and fell onto Highway 226 north of Brewster Road. The plane came to rest several thousand feet south of the intersection in a cow pasture.

The aircraft was a two seat experimental RV6 that was completed in 1996.  Investigators believe the aircraft departed the Lebanon Municipal Airport shortly before 3:30 pm on a pleasure flight.

The Linn County Sheriff's Office is coordinating the ongoing investigation with the FAA and NTSB. The Scio Rural Fire District assisted on scene with extrication. LCSO was further assisted on scene by members of the Multi Agency Investigation Team with representatives from the Oregon State Police, Linn County Sheriff's Search and Rescue, the Albany Police Department and the Lebanon Police Department.

The intersection of Highway 226 and Brewster Road was closed by representatives of ODOT and the Linn County Road Department for approximately four hours during the investigation.

SCIO, Ore. - Debris from a small plane crash closed Oregon Highway 226 on Monday.

No word yet on the condition of the pilot and whether there were any passengers aboard the plane.

The crash was reported to 911 at 3:37 p.m. Monday.

Initial reports indicate the plane crashed in a field near a rural residential area near Hwy 226 and Brewster Road.

Firefighters from Lebanon and Scio responded to the scene.

As of 4:45 p.m., neither the Linn County Sheriff's Office nor the fire crews who responded were certain how many people were on board the plane or what exact type of aircraft crashed.

'The status of those on board is also unknown at this time," firefighters said in a press release.

The Oregon Department of Transportation said Hwy 226 (the Albany-Lyons Highway) is closed 6 miles south of Scio.

Motorists should plan an alternate route, ODOT said.

The crash did not occur on the highway but debris from the crash has landed on the highway and will likely not be cleared until an investigation is completed, ODOT said.

LEBANON, OR (KPTV) -  Emergency crews responded to a plane crash in Linn County Monday.

The call came in to authorities around 3:30 p.m. It involves a small, private plane that crashed in a field near Highway 226 and Brewster Road about nine miles east of Albany, according to authorities.

Firefighters and deputies were called out to the scene, but there is not yet any word about possible injuries.

The Oregon Department of Transportation said Highway 226 was closed about six miles south of Scio. The crash did not happen on the highway, but ODOT said debris from the plane crash went on the roadway and it likely wouldn't be cleared until the investigation was completed.

The Linn County Sheriff's Office is handling the investigation. 

SCIO, Ore. -- A small plane has crashed south of Scio, in Linn County, according to witness reports.

The Oregon Department of Transportation has issued a warning for drivers that there is some debris from the plane crash on OR 226, also known as the Albany-Lyons Highway, about six miles south of Scio.

Motorists were warned to avoid the area and a detour was also being set up.

ODOT officials said the crash did not occur on the highway but debris landed on the highway and will likely not be cleared until an investigation is completed.
  

ALBANY, Ore. – Sheriff’s deputies in Linn County are investigating a small plane crash near Albany.

The plane crashed in a field near Brewster Road and Highway 226 at around 3:30 p.m., deputies said.

The rural area is located about nine miles east of Albany.

It’s unclear how many people were on the plane or what caused the crash.

Debris from the crash closed Highway 226 south of Scio. Deputies said the debris will likely not be removed until the investigation is completed.

A small plane has crashed into a field east of Albany and its debris has closed Oregon 226 Monday, authorities said.

The crash was reported about 3:30 p.m. near Brewster Road and Oregon 226, said Lebanon Fire District. Details on how the crash occurred and if there are any injuries has not been released.

The Oregon Department of Transportation said the plane did not crash on the roadway and the debris will not be cleared until an investigation is finished.

The Linn County Sheriff's Office and the Federal Aviation Administration are investigating the crash.

 Officials with the Linn County Sheriff’s Office are investigating a plane crash that occurred in a field approximately nine miles east of Albany Monday afternoon.

The plane crashed in a field near a rural residential area near Brewster Road and Highway 226. It is unknown at this time how many people were aboard the aircraft or if anyone on the plane or the ground was injured. The aircraft was confirmed to be a small plane, although the specific model or its use is unknown at this time.

Debris from the crash has closed Highway 226 six miles south of Scio in Linn County. Officials said the debris will likely not be cleared until the investigation of the crash has been completed.
CRABTREE — Firefighters and law enforcement officials were called to the scene of a plane crash late Monday afternoon near Crabtree.

A small plane left a trail of debris before it came to rest in a field just west of Brewster Road off of Highway 226. It was unknown how many people were in the plane when it went down or if there were any survivors.

About 14 vehicles from various city, county and state agencies were deployed to the scene. As the sun was setting around 5 p.m., firefighters were trying to mark where debris was spotted.

The plane left at least one large piece on the north shoulder of Highway 226. Additional wreckage was scattered on both sides of Brewster Road.

Traffic was being diverted on Highway 226 about a half-mile away from the scene in both directions and also northbound on Brewster Road. 

Linn County sheriff's deputies are investigating a small plane crash east of Albany, Ore., that scattered enough debris to temporarily close a nearby state highway. There was no immediate word on the status of those aboard the plane.

Undersheriff Bruce Riley said in a statement that the plane crash was reported at about 3:30 p.m. Monday. He said his office did not immediately know the extent of any injuries nor the identity of those aboard.

The plane reportedly crashed in a field in a rural residential area about nine miles east of Albany in the Willamette Valley.

The Oregon Transportation Department says debris from the crash closed state Highway 226 about six miles south of Scio.

The Federal Aviation Administration has been notified.

ALBANY, Ore. (KMTR) -- Linn County Undersheriff Bruce Riley reports that deputies are currently investigating a report of a plane crash. Today at approximately 3:37 PM the sheriff's office received a 911 call reporting that a small plane had crashed in the area of Brewster Road and Highway 226. This rural residential area is located approximately nine miles east of Albany. 

Initial reports indicate the plane crashed in a field. At the time of this release the Sheriff's Office has not confirmed the cause of the crash, identity of occupants or extent of injuries. As with all plane crashes, the FAA has been notified.