14 CFR Part 91: General Aviation
Accident occurred Saturday, September 01, 2012 in McVeytown, PA
Probable Cause Approval Date: 04/10/2013
Aircraft: JOHNSTON DOUGLAS S SAFARI, registration: N70415
Injuries: 1 Fatal.
NTSB investigators may not have traveled in support of this investigation and used data provided by various sources to prepare this aircraft accident report.
A witness who spoke with the pilot before the flight reported that the pilot had checked the fuel before departure and intended to "make a couple of laps" before proceeding to a local airport to purchase more fuel. Another witness observed the helicopter perform two 180-degree turns before it descended and impacted the ground. Examination of the accident site confirmed a vertical impact, and the helicopter damage was consistent with low or minimal rotor speed at the time of impact. Inspection of the fuel system revealed no fuel in the right fuel tank and about 2 pints of fuel in the left fuel tank. No contamination was observed in the fuel on board, and no obstructions were observed in the fuel system.
The experimental amateur-built helicopter was constructed from a kit and received its airworthiness certificate in 2003. The pilot purchased the helicopter about 4 months before the accident through the kit manufacturing company, which was brokering the sale of the helicopter for the builder’s estate. The pilot did not hold a pilot certificate and did not register the helicopter with the FAA. Examination of the pilot's logbook revealed that about 2 years before the accident, he had received 3.2 hours of helicopter instruction. Interviews revealed that when the pilot acquired the helicopter, he flew an additional 15 hours with the owner of the helicopter kit manufacturing company (in the accident helicopter and another company helicopter). However, these flights were limited to hover practice.
It is likely that while the pilot was maneuvering the helicopter at a low altitude, it experienced a loss of engine power due to fuel exhaustion. At this point, the pilot needed to immediately enter an autorotation. However, given the pilot’s limited flight training and his lack of pilot certification (he would have had to demonstrate an autorotation in order to become a certificated helicopter pilot), he almost certainly was not proficient in performing autorotations. The helicopter’s vertical impact with low rotor rpm is consistent with the pilot failing to make the control inputs necessary to enter an autorotation.
The National Transportation Safety Board determines the probable cause(s) of this accident to be:
The pilot's lack of proficiency and certification, which resulted in his failure to enter an autorotation when the engine lost power. Contributing to the accident was the pilot’s inadequate fuel planning, which resulted in fuel exhaustion and a subsequent loss of engine power.
HISTORY OF FLIGHT
On September 1, 2012, at 0900 eastern daylight time, N70415, experimental amateur-built Safari helicopter was substantially damaged when it impacted the ground while maneuvering in McVeytown, PA. The non-certificated pilot was fatally injured. Visual meteorological conditions prevailed for the personal, local flight that was conducted under the provisions of 14 CFR Part 91.
According to a witness, he observed the helicopter flying away from him, and then made a 180-degree turn toward the hangar it was kept in. The helicopter then made another 180-degree turn and "started to go down." The witness observed a puff of smoke as the helicopter disappeared from his view.
PILOT INFORMATION
A review of the Federal Aviation Administration (FAA) database revealed the pilot did not hold a pilot certificate.
According to a pilot logbook provided by the pilot's wife, he logged three flights on: August 14, 2010, August 21, 2010, and October 9, 2010. The total flight time for these flights was 3.2 hours.
AIRCRAFT INFORMATION
The helicopter was built from a kit, by the previous owner, and received its first airworthiness certificate on April 10, 2003. It was equipped with a Lycoming O-320, 160-horsepower engine.
The accident pilot purchased the helicopter in March 2012; however, there was no evidence that he attempted to acquire an airworthiness certificate or register the helicopter with the FAA.
A review of the helicopter and engine logbooks revealed the most recent condition inspection was completed on June 30, 2011 by the previous owner/builder. No anomalies were noted in the entry, and a tachometer time of 395 hours was noted.
The tachometer time at the accident site was 442 hours.
According to the kit manufacturer, they brokered the sale of the helicopter between the accident pilot and the widow of the previous owner/builder. After the accident pilot purchased the helicopter, the kit manufacturer performed some maintenance on it to assure it was in a flyable condition. The work they performed included: replacing the main rotor spindle, and performing an annual condition inspection. This work was completed on May 11, 2012.
METEOROLOGICAL INFORMATION
The weather recorded at the nearest airport, at 0853, included wind from 280 degrees at 7 knots, 10 miles visibility, a broken cloud layer at 7,000 feet, temperature 23 degrees C, dew point 19 degrees C, and altimeter setting 30.13 inches mercury.
WRECKAGE INFORMATION
Examination of the accident site confirmed the helicopter impacted the ground in a vertical attitude with minimal forward speed. Inspection of the main rotor blades and tail rotor blades revealed damage consistent with low or minimal rotor speed (RPM) impact with terrain. Main and tail rotor control system continuity was confirmed from the cockpit to the control surfaces. Inspection of the fuel system revealed no fuel in the right fuel tank and approximately 2 pints in the left fuel tank. A sample of fuel from the left tank was found to be free of contamination and consistent with 100LL aviation fuel. The carburetor bowl drain was opened and fuel was observed. No obstructions were noted in the fuel system, or the air induction system. The fuel selector was in the ON position.
The engine crankshaft was rotated at the propeller flange and thumb compression and valve train continuity was confirmed on all four cylinders. No mechanical anomalies were noted during the engine examination. [Additional information regarding the on-scene helicopter examination can be found in the FAA Inspector Statement located in the public docket.]
MEDICAL AND PATHOLOGICAL INFORMATION
The Mifflin County Coroner performed an autopsy on the pilot on September 1, 2012. The cause of death was listed as blunt force trauma.
The FAA Toxicology and Accident Research Laboratory, Oklahoma City, Oklahoma conducted toxicological testing on the pilot. No drugs or alcohol were noted in the testing.
ADDITIONAL INFORMATION
A witness who spoke with the pilot prior to the flight reported that the pilot had "five and a half inches" of fuel in the helicopter prior to departure. He reported the pilot intended to "make a couple of laps," and then they were going to fly to the local airport to purchase more fuel.
According to the kit manufacturer, when the pilot arrived at their facility to acquire the helicopter in May 2012, the owner of the kit manufacturing company flew with the pilot for about 15 hours (both in a company helicopter and in the accident helicopter). The purpose of these flights was for the pilot to practice hovering the helicopter. Because the pilot did not have a pilot's license and was not familiar with this type of helicopter, the company owner told him not to lift the helicopter more than 2 feet off the ground, once he arrived home, until he received instruction in it.
According to the pilot's wife, she believed the pilot flew the helicopter for the first time after it arrived at their home from the manufacturer's facility, on July 4, 2012. She estimated the pilot flew approximately every other weekend since then (three times in July and two in August).The pilot's wife believed the flights only included the pilot practicing lifting the helicopter off the ground and setting it back down again. He may have circled the field where he kept the helicopter, but she believed that would have been the longest duration of a flight. The pilot's wife was not aware that he intended to fly the helicopter on the day of the accident.
A review of the Height-Velocity diagram contained in the Safari Helicopter Flight Manual revealed that operations below an altitude of 400 feet and below airspeeds of 50 knots should be avoided.
According to the FAA Rotorcraft Flying Handbook, FAA-H-8083-21, the height/velocity (H/V) diagram depicts critical combinations of airspeed and altitude should an engine failure occur. Operations in crosshatched or shaded areas of the H/V diagram may not allow enough time for the critical transition from powered flight to autorotation.
NTSB Identification: ERA12LA541
14 CFR Part 91: General Aviation
Accident occurred Saturday, September 01, 2012 in McVeytown, PA
Aircraft: JOHNSTON DOUGLAS S SAFARI, registration: N70415
Injuries: 1 Fatal.
This is preliminary information, subject to change, and may contain errors. Any errors in this report will be corrected when the final report has been completed. NTSB investigators may not have traveled in support of this investigation and used data provided by various sources to prepare this aircraft accident report.
On September 1, 2012, at 0900 eastern daylight time, N70415, experimental amateur-built Safari helicopter was substantially damaged when it impacted the ground while maneuvering in McVeytown, PA. The non-certificated pilot was fatally injured. Visual meteorological conditions prevailed for the personal, local flight that was conducted under the provisions of 14 CFR Part 91.
According to a Federal Aviation Administration inspector, the pilot was maneuvering over his property when witnesses heard the engine "skip." The helicopter subsequently descended vertically and impacted a field.
Examination of the accident site confirmed the helicopter impacted the ground with no evidence of forward speed. A preliminary examination of the helicopter revealed cyclic, collective, and tail rotor control continuity.
The helicopter was removed from the scene and secured for a subsequent examination.
The weather recorded at the nearest airport, at 0853, included wind from 280 degrees at 7 knots, 10 miles visibility, a broken cloud layer at 7,000 feet, temperature 23 degrees C, dew point 19 degrees C, and altimeter setting 30.13 inches mercury.
Johnston Douglas S SAFARI, N70415: Accident occurred September 1, 2012 in McVeytown, Pennsylvania
IDENTIFICATION
Regis#: 70415 Make/Model: EXP Description: SAFARI HELICOPTER
Date: 09/01/2012 Time: 1400
Event Type: Accident Highest Injury: Fatal Mid Air: N Missing: N
Damage: Substantial
LOCATION
City: MCVEYTOWN State: PA Country: US
DESCRIPTION
EXPERIMENTAL HELICOPTER CRASHED IN A FIELD, THE 1 PERSON ON BOARD WAS
FATALLY INJURED, NEAR MCVEYTOWN, PA
INJURY DATA Total Fatal: 1
# Crew: 1 Fat: 1 Ser: 0 Min: 0 Unk:
# Pass: 0 Fat: 0 Ser: 0 Min: 0 Unk:
# Grnd: Fat: 0 Ser: 0 Min: 0 Unk:
OTHER DATA
Activity: Unknown Phase: Unknown Operation: OTHER
FAA FSDO: HARRISBURG, PA (EA13) Entry date: 09/04/2012
http://www.airport-data.com/aircraft/N70415.html
http://registry.faa.gov/N70415
McVEYTOWN — A McVeytown man was killed Saturday morning when his helicopter crashed into a farm field in Wayne Township, Mifflin County. County Coroner Daniel Lynch identified the victim as Kenneth M. Smith, 61. Smith was piloting the 2-seat helicopter when the engine shut off and the aircraft crashed. He was killed on impact, Lynch said. State police and the Federal Aviation Administration also are investigating. Read Full Article
Kenneth M. Smith
McVEYTOWN - Kenneth M. Smith, 61, of 90 Pine Hill Road, McVeytown, Pennsylvania, died at 9:20 a.m. Saturday, Sept. 1, 2012, as a result of injuries sustained in a helicopter accident near his home.
Mr. Smith was born on June 27, 1951, in Wayne Township, Mifflin County, a son of James M. Smith and the late Thelma J. (Ranck) Smith, of McVeytown. He married Carol J. Pollicino on April 24, 1992, in Winchester, Va. She survives at their home. He also is survived by: children, Tracey L. Carolus and husband, David, of Milroy, and Ken J. Smith, of Dillon Beach, Calif.; a stepson, Nathan E. Longacre, of Mount Union; a granddaughter, Katelyn S. Carolus; and siblings, Dorothy Gearhart, of McVeytown, Peggy Souders and husband, Sam, of Newton Hamilton, Sandra Scott and husband, Eric, of McVeytown, Tammy Worthy and husband, Neal, of Shirleysburg, and Tina S. Smith, of Warfordsburg.
Mr. Smith was the owner of K M Smith & Son Logging and Land Clearing, a business that started with his father, with whom he worked, even as a child, and continued to operate after his father's retirement.
He was a 1969 graduate of Mount Union Area High School.
Mr. Smith was a member of the F & AM Lodge 688, Mount Union.
He was well known as a sprint car owner and driver and raced for many years primarily at Port Royal Speedway. He was also involved in drag-racing, particularly at Beaver Springs, and raced go-karts in his younger years at area tracks.
Mr. Smith will be remembered for his strong work ethic and his generosity to others. He also was proud of his special bond with his granddaughter Katelyn and his constant companion, his dog Belle.
Funeral service will be held at 11 a.m. Wednesday, Sept. 5, 2012, at the Robert D. Heath Funeral Home, Mount Union, with Pastor Brian Myfelt officiating. The interment will be in the Atkinson Mills Methodist Cemetery.
The family will receive friends at the funeral home from 7 to 9 p.m. Tuesday evening, and from 9 a.m. until the time of the service, on Wednesday.
Memorial contributions can be made to the Huntingdon County Humane Society, 11371 Schoolhouse Hollow Rd, Huntingdon, PA 16652, or the American Cancer Society, PO Box 22718, Oklahoma City, OK 73123.
Source: http://lewistownsentinel.com
No comments:
Post a Comment