NTSB Identification: DCA16LA032
Scheduled 14 CFR Part 121: Air Carrier operation of Southwest Airlines
Accident occurred Tuesday, December 15, 2015 in Nashville, TN
Probable Cause Approval Date: 01/23/2017
Aircraft: BOEING 737 3H4, registration: N649SW
Injuries: 138 Uninjured.
NTSB investigators may not have traveled in support of this investigation and used data provided by various sources to prepare this aircraft accident report.
On December 15, 2015, at 5:23pm central standard time (CST), Southwest Airlines flight 31, a Boeing 737-300, N649SW, exited the taxiway while taxing to the gate and came to rest in a ditch at the Nashville International Airport (BNA), Nashville, Tennessee. Nine of the 138 passengers and crew onboard received minor injuries during the evacuation and the airplane was substantially damaged. The airplane was operating under the provisions of 14 Code of Federal Regulations Part 121 as a regularly scheduled passenger flight from William P. Hobby Airport (HOU), Houston, Texas. Weather was not a factor, light conditions were dark just after sunset.
The airplane landed normally on runway 20R and exited at taxiway B2. The flight crew received and understood the taxi instructions to their assigned gate. As the crew proceeded along taxiway T3, the flight crew had difficulty locating taxiway T4 as the area was dark, and there was glare from the terminal lights ahead. The crew maneuvered the airplane along T3 and onto T4, and then turned back to the right on a general heading consistent with heading across the ramp toward the assigned gate. The flight crew could not see T4 or the grassy area because the taxiway lights were off and the glare from the terminal lights. As a result, the airplane left the pavement and came to rest in a drainage ditch resulting in substantial damage to airplane. The cabin crew initially attempted to keep the passengers seated, but after being unable to contact the flight crew due to the loud alarm on the flight deck, the cabin crew properly initiated and conducted an evacuation.
As a result of past complaints regarding the brightness of the green taxiway centerline lights on taxiways H, J, L and T-6, BNA tower controllers routinely turned off the taxiway centerline lighting. Although the facility had not received any requests on the day of the accident, about 30 minutes prior to the event the tower controller in charge (CIC) turned off the centerline lights as a matter of routine. In doing so, the CIC inadvertently turned off the "TWY J & Apron 2" selector, which included the taxiway lights in the vicinity of the excursion. The airfield lighting panel screensaver feature prevented the tower controllers from having an immediate visual reference to the status of the airfield lighting.
The National Transportation Safety Board determines the probable cause(s) of this accident as follows:
the flight crew's early turn towards the assigned gate because taxiway lighting had been inadvertently turned off by the controller-in-charge which resulted in the airplane leaving the paved surface.
Contributing to the accident was the operation of the screen-saver function on the lighting control panel that prevented the tower controllers from having an immediate visual reference to the status of the airfield lighting.
HISTORY OF FLIGHT
On December 15, 2015, at 5:23pm central standard time (CST), Southwest Airlines flight 31, a Boeing 737-300, N649SW, exited the taxiway while taxing to the gate and came to rest in a ditch at the Nashville International Airport (BNA), Nashville, Tennessee. Nine of the 138 passengers and crew onboard received minor injuries during the evacuation and the airplane was substantially damaged. The airplane was operating under the provisions of 14 Code of Federal Regulations Part 121 as a regularly scheduled passenger flight from William P. Hobby Airport (HOU), Houston, Texas.
The airplane landed normally on runway 20R and exited at taxiway B2. ATC instructed the flight to taxi to the ramp (gate C20) via taxiway B, T3, and T4. (Figure 1)
The captain reported he used landing lights to assist in the taxi along B and T3 and then extinguished the landing lights as the airplane crossed runway 13/31, but left the taxi lights on. Video surveillance footage was consistent with the captain's report. The flight crew reported that they had difficulty locating taxiway T4 as it appeared dark and there was glare from the terminal lights ahead. About 15 seconds prior to the excursion the airplane began a left turn briefly to a heading of about 065 degrees. Taxiway T4 was oriented about 045 degrees. Crew reports, and the cockpit voice recorder (CVR) recording, indicate the crew was searching for the turn to the ramp when flight data recorder (FDR) data and video surveillance footage indicated the airplane then turned back to the right to a heading of 090 degrees, consistent with the heading toward gate C20. Three seconds later the airplane exited the taxiway into a grassy area with a large drainage ditch, east of the intersection of taxiways T4 and J. The nosegear collapsed, and the airplane came to rest angled to the right, on the left nacelle, right wing tip, and nose. (Figure 2)
Shortly after the airplane came to rest, the CVR recording indicated, an audible alarm began sounding in the cockpit which the flight crew indicated they could not silence (see Tests and Research section). The pilot advised ATC that "we've cut the corner here and are off in the grass" and asked for ARFF equipment.
According to the flight attendant (FA) statements, there was a large jolt and loud bang when the airplane stopped and all the cabin lights went out for some time before the emergency lights came on. The FAs stated that they did not know what was going on so began yelling, "heads down, stay down" as they tried to call the pilots but there was no power on the interphones. The FAs initiated the evacuation a short time later. About one minute after the airplane came to rest, the pilots noticed that the slides were deploying and passengers were evacuating and the captain announced on the public address system "okay don't evacuate flight attendants, do not evacuate" to which the first officer responded "oh they are already going."
Review of Air Traffic records and interviews with controllers revealed that about 30 minutes prior to the accident the taxiway lights for "TWY J & Apron 2" were selected "off." This resulted in shutting off the lights for taxiways L and J; taxiways T4 and T5 to the northeast of L; the lights along the edge of the ramp parallel to J; and the connector and circular area between Concourses B and C.
INJURIES TO PERSONS
Nine of the 133 passengers received minor injuries during the evacuation. None of the five crew members were injured.
DAMAGE TO AIRCRAFT
The nose landing gear collapsed in a rearward direction resulting in substantial damage to frames, stringers, and the bulkhead aft of the nose gear well. Additional minor damage to engine nacelles, fairings, and skin was also found.
PERSONNEL INFORMATION
The captain, age 58, had worked for Southwest Airlines since 1999. He held an Airline Transport Pilot certificate, multi-engine land, with a type rating in the B737. He held an FAA first class medical certificate with a limitation for glasses for near vision. Company records indicate that he had approximately 19,300 hours total time with approximately 14,100 hours in the B737. He had no previous accidents, incidents, or violations. He had flown to Nashville numerous times previously.
The first officer, age 61, had worked for Southwest Airlines since 2006. He held an Airline Transport Pilot certificate, multi-engine land, with type ratings in the B-727, B-737, B-757, B-767, CL-30, and DC-9. He held an FAA first class medical certificate with a limitation for glasses for near vision. Company records indicated a total time of approximately 15,500 hours, with approximately 5400 hours in the B737. He had no previous accidents, incidents, or violations. He had flown to Nashville numerous times previously.
The three flight attendants were all current and qualified on the B737.
AIRCRAFT INFORMATION
N649SW, manufacturer serial number 27719, was a Boeing 737-3H4 equipped with CFM-56-3B1 engines. The airplane had accumulated approximately 58,630 hours total time on the airframe. Recorded data and airline records indicated no relevant maintenance issues with the airplane.
METEOROLOGICAL INFORMATION
The Nashville Airport 5:05pm weather observation indicated clear conditions with 10 miles visibility, wind from 180 degrees at 3 knots, temperature 17º C. There was no precipitation. Night lighting conditions prevailed, local sunset was at 4:34pm.
COMMUNICATIONS
After the airplane came to rest, the pilot advised the tower that he that he had "cut the corner" and requested assistance. There were no further communications between the flight crew and the tower. The flight crew reported that a loud audible alarm in the cockpit, which they could not silence, impeded communication.
AERODROME INFORMATION
The Nashville International Airport (BNA) is located approximately 5 miles southeast of the city of Nashville, Tennessee. The airport averages almost 500 operations per day, mostly air carrier and air taxi activity. Runway 20R is 7,704 feet long and 150 feet wide, aligned to 201 degrees magnetic.
The airfield lighting at BNA consisted of taxiway edge and taxiway centerline lights, runway edge and runway centerline lights, runway end identifier lights, approach lights, and a rotating beacon. The airfield lighting was controlled via two airfield lighting touchscreen control panels located near the local controller (LC) and ground controller (GC) positions in the control tower. The BNA air traffic control tower (ATCT) standard operating procedures (SOP), BNA Order 7111.1B, dated July 24, 2014, did not specify who had overall responsibility for the operation of the airfield lighting.
The airfield lighting panels (Figure 3) were owned by the Metropolitan Nashville Airport Authority (MNAA) and were operated using software installed in 2010. The airfield lighting was operated in accordance with requirements contained in FAAO 7110.65, Air Traffic Control, and a letter of agreement between the control tower and MNAA dated December 16, 2013.
The lighting panel had preset intensity selections used according to current weather/day/night conditions and was operated by the tower controllers via a touch screen that selected lighting intensities as required by the current conditions. Specific airfield lighting configurations could be selected to operate independently of the pre-set conditions, such as turning off a specific taxiway lighting circuit. The touch screen control circuit that activated or deactivated the taxiway centerline lights was located next to the touch screen control circuit that activated or deactivated the lighting for the ramp/apron and a portion of taxiway T4.
The lighting panels had a screensaver mode that caused the screen to go black after approximately five minutes if the panel was not accessed by a controller.
ATCT staff informed investigators that as a result of past complaints regarding the brightness of the green taxiway centerline lights on taxiways H, J, L, and T6, BNA tower controllers routinely turn off the centerline lighting. On the date of the accident the facility had not received any specific request to turn off the centerline lights; however, prior to the event, the controller in charge (CIC) attempted to turn off the centerline lights as a matter of routine. In doing so, the CIC inadvertently turned off the "TWY J & Apron 2" selector.
The CIC was later notified by Airport Operations that the lights were off, and he turned them back on approximately 25 minutes after the incident.
Subsequent to the accident, Nashville ATCT modified their standard operating procedure regarding responsibility for taxiway lighting and eliminated the lighting panel screensaver function.
FLIGHT RECORDERS
The solid-state flight data recorder (FDR), a Honeywell SSFDR, model 980-4700, records a minimum of 25 hours of airplane flight information in a digital format. The FDR was in good condition, and the data were extracted normally from the FDR.
The solid-state cockpit voice recorder (CVR) was a Honeywell 6022 SSCVR 120 that recorded 2 hours of digital cockpit audio. The audio information was extracted from the CVR normally, without difficulty. The quality of the audio was characterized as good to excellent. No CVR group was convened, and a summary was prepared by the NTSB recorders lab.
SURVIVAL ASPECTS
The cabin crew consisted of three flight attendants (FA). The lead A-FA was seated at the outboard position of a dual jumpseat located in the forward entry area next to door L1. The B-FA was seated at the outboard position of a dual jumpseat located in the aft galley next to door L2. The C-FA was seated at the inboard position of a dual jumpseat located in the forward entry area next to door L1. All three flight attendants stated the aircraft landed normally and was taxing to the gate when it came to an unexpected abrupt stop. The loud sounds and unusual attitude of the airplane alerted the FAs that there was a problem. All three flight attendants stated they waited for the pilots to contact them with further instructions. Passengers had started getting out of their seats and were moving around the cabin, so both the A-FA and C-FA started using their emergency commands "heads down, stay down" to control passenger movement. The A-FA attempted to use the interphone to call the cockpit, but was not successful because it was not powered. The A-FA and C-FA discussed the aircraft attitude, loud sounds and lack of communication from the cockpit and initiated an evacuation using only door R1 (the A-FA had assessed door L1 and observed the left engine on the ground and decided to block the exit). The C-FA operated door R1 while the A-FA tried contacting the pilots for the second time with no success. The B-FA heard evacuation commands coming from the forward cabin and started yelling evacuation commands in the aft cabin. She turned on the emergency light switch located on the aft jumpseat panel and opened her primary (L2) exit door first, followed by her secondary (R2) exit door. After all the passengers had evacuated the aircraft, the FA's checked the cabin, gathered emergency equipment and exited the aircraft. They staged outside on the tarmac to keep passengers a safe distance from the aircraft.
TESTS AND RESEARCH
The flight crew reported that a loud alarm in the cockpit, that they were unable to silence, distracted them from communicating with the cabin crew. A review of the sound by a Boeing test pilot confirmed that the alarm was consistent with the gear unsafe alarm, and could not be silenced without disabling a circuit breaker or running a checklist procedure for an unrelated scenario.
Scheduled 14 CFR Part 121: Air Carrier operation of Southwest Airlines
Accident occurred Tuesday, December 15, 2015 in Nashville, TN
Aircraft: BOEING 737 3H4, registration: N649SW
Injuries: 138 Uninjured.
This is preliminary information, subject to change, and may contain errors. Any errors in this report will be corrected when the final report has been completed. NTSB investigators may not have traveled in support of this investigation and used data provided by various sources to prepare this aircraft accident report.
On Tuesday, December 15, 2015 at 1725 central standard time, Southwest Airlines flight 31, a Boeing 737, N649SW, departed taxiway T4 and came to rest in a ditch at the Nashville International Airport, (BNA), Nashville, Tennessee. The passengers evacuated via the emergency slides. The aircraft was substantially damaged and nine passengers sustained minor injuries. The flight was a regularly scheduled passenger flight from the William P Hobby Airport (HOU), Houston, Texas. Night visual meteorological conditions prevailed at the time of the accident.
The FAA on Wednesday morning continued to investigate what caused a Southwest plane to skid off a taxiway at the Nashville International Airport and land in a ditch, injuring at least eight passengers.
Southwest Flight 31, a Boeing 737 carrying 133 passengers and five crew members, rolled off taxiway T4 near the terminal into the grass and came to a halt about 5:20 p.m. Metropolitan Nashville Airport Authority officials said emergency personnel immediately responded, along with Nashville fire department crews to assist passengers hurt in the wreck.
Airport spokeswoman Shannon Sumrall said Southwest brought in a recovery team early Wednesday to pull the plane out of the ditch with a crane and then moved it to another location at the terminal.
All runways were open and operational Wednesday morning and there were no delays, she said.
Southwest officials said the plane departed from Houston Hobby Airport at 4 p.m. and landed just before 5:20 p.m. Passengers said it was a full plane.
FAA spokeswoman Kathleen Bergen said her agency on Wednesday continued to investigate what went wrong.
The National Transportation Safety Board may also come in to investigate the cause of the wreck. If that happens, Bergen said, that agency will head the investigation.
"It's a taxing event, so we are monitoring the situation and awaiting a damage estimate," NTSB spokesman Eric Weiss said Wednesday.
Substantial damage to the aircraft will determine whether NTSB leads the investigation, Weiss said.
After the incident, passengers left the aircraft and were bused to the terminal, Bergen said. Photos from the scene showed at least one of the plane's emergency slides deployed.
Fire spokesman Brian Haas said three ambulances transported eight people to TriStar Summit Medical Center.
Most of those passengers suffered minor injuries, mostly bumps and bruises, Haas said, and one person was suffering from chest pains.
So far no additional injuries have been reported overnight, he said.
Passengers described hearing a loud noise while the plane was taxiing, feeling the plane tilt slightly and then the plane coming to a stop in the ditch. After the accident, many were checking on the status of their bags at the Southwest baggage claim area.
Joe Caverlee, from Westmoreland, said he'd been at the airport about two hours after the crash and felt lucky it wasn't worse.
"The flight crew was awesome," he said "They told everyone to keep down, to keep down. The emergency doors opened in the front and back and we were out of there in minutes."
Reginald Smith Jr., who was on the plane, called the landing frightening.
"We landed, we were coasting and then we were bouncing up and down and the next thing you know ... it felt as if we were about to topple over as we were going into the ditch," said Smith as he stood inside the airport terminal. "You could feel the plane hit and stop. It was terrifying."
Smith, who said he flew from Houston to sing in the Nashville Symphony, said after the crash that many passengers on the plane quickly helped crew members assist elderly and disabled passengers off the plane first.
Another passenger, Andy Borchers, said the plane's emergency lights lit after the plane hit the ditch, crew members opened an emergency door and everyone on board slid down one-by-one.
“There was no urgency, we weren’t moving at a high speed,” Borchers said. “Everyone was in pretty good spirits,” he said. “But the flight attendants were shaken up.”
Recent airplane accidents in Tennessee
June 15, 2011: A Cessna 525A was significantly damaged, while a student pilot was in the cockpit and overran a runway at John C. Tune airport in Nashville. The pilot-in-charge took the controls while landing, after he reportedly failed to execute a go-around when the airplane was at a high-speed with the student, No one was injured.
Oct. 29, 2013: A drunken Canadian pilot crashed his plane on a runaway at the Nashville International Airport. He was the only passenger on the plane and was announced dead at the scene. He filed a 30 minute trip from Windsor, Ontario, down to Pelee Island in Lake Erie, but crossed the southern border undetected, then circled Tune for hours before crashing. A pilot spotted the debris and reported to airport officials.
Feb. 3, 2014: A Gulfstream 690C, coming from Kansas to Nashville, made two attempts to land before crashing near the YMCA in Bellevue, killing all four people on board. The airplane had maintenance done days before in Oklahoma City. The aircraft veered left just before crashing about 10 miles southwest of John C. Tune airport.
Dec. 26, 2014: A Cessna 162 overturned after making a hard landing at John C. Tune airport. No one was injured in the small airplane crash, as the first emergency personal called off additional help.
Aug. 7, 2015: A Delta flight headed to Cincinnati out of BNA caught fire for several seconds. As the plane pushed from the jet bridge, the engine turned on and caught fire immediately. The pilot, then, turned off the engine and the fire extinguished itself. The plane was taken back to the gate. No one was injured and the passengers booked new flights.
Story, photo gallery and video: http://www.tennessean.com
Southwest Airlines released a statement on the incident.
“At approximately 5:30 p.m. local time, Southwest Airlines flight 31 from Houston Hobby Airport to Nashville International Airport exited the taxiway shortly after arriving into Nashville, as the airplane was approaching the gate. The 133 passengers and five Crewmembers were safely transported into the airport, and we are currently working to support their needs. The Safety of our Customers and Employees remains our primary focus.”
A Southwest plane carrying passengers and a crew from Houston rolled off a taxiway into the grass and got stuck in a ditch at the Nashville International Airport Tuesday, injuring at least eight people, authorities said.
FAA spokeswoman Kathleen Bergen said Southwest Flight 31, a Boeing 737, rolled off taxiway T4 near the terminal into the grass and came to a halt about 5:20 p.m. Central time. Metropolitan Nashville Airport Authority officials said emergency personnel immediately responded, along with Nashville fire department crews.
Southwest officials said the plane that carried 133 passengers and five crew members departed from Houston Hobby Airport at 4 p.m. Central time. Passengers said it was a full plane.
Passengers left the aircraft and were bused to the terminal, Bergen said. Photos from the scene showed at least one of the plane's emergency slides deployed.
Fire spokesman Brian Haas said three ambulances transported eight people to TriStar Summit Medical Center.
Most of those passengers suffered minor injuries, mostly bumps and bruises, Haas said, and one person was suffering from chest pains.
Passengers described hearing a loud noise while the plane was taxiing, feeling the plane tilt slightly and then the plane coming to a stop in the ditch. After the accident, many were checking on the status of their bags at the Southwest baggage claim area.
Joe Caverlee, from Westmoreland, said he'd been at the airport about two hours after the crash and felt lucky it wasn't worse.
"The flight crew was awesome," he said "They told everyone to keep down, to keep down. The emergency doors opened in the front and back and we were out of there in minutes."
Reginald Smith Jr., who was on the plane, called the landing frightening.
"We landed, we were coasting and then we were bouncing up and down and the next thing you know ... it felt as if we were about to topple over as we were going into the ditch," said Smith as he stood inside the airport terminal. "You could feel the plane hit and stop. It was terrifying."
Smith, who said he flew from Houston to sing in the Nashville Symphony, said after the crash that many passengers on the plane quickly helped crew members assist elderly and disabled passengers off the plane first.
Another passenger, Andy Borchers, said the plane's emergency lights lit after the plane hit the ditch, crew members opened an emergency door and everyone on board slid down one-by-one.
“There was no urgency, we weren’t moving at a high speed,” Borchers said. “Everyone was in pretty good spirits,” he said. “But the flight attendants were shaken up.”
The incident remains under investigation by the FAA.
Airport officials said all runways were open and operational and there were no delays after the crash.
Source: http://www.wbir.com
No comments:
Post a Comment